1. Ingeniería

TOWN OF FUQUAY-VARINA
BID DOCUMENTS
FOR
CONSTRUCTION OF A CONCESSION/RESTROOM FACILITY
FALCON PARK
TOWN OF FUQUAY-VARINA
401 OLD HONEYCUTT ROAD
FUQUAY-VARINA, NC
BID TIME:
BID DATE:
BIDDER:
10:00 AM
JANUARY 30, 2015
______________
December 2014
ADVERTISEMENT FOR BIDS
Falcon Park Concession/Restroom Facility
Fuquay-Varina, North Carolina
Separate, sealed informal bids will be received by the Town of Fuquay-Varina for the construction of a
Concession/Restroom Facility at Falcon Park – Town of Fuquay-Varina, North Carolina.
1)
Bid documents may be examined and/or obtained during normal weekday office hours
beginning Tuesday, January 6, 2015 at the Fuquay-Varina Community Center. The
Fuquay-Varina Community Center is located at 820 South Main Street, Fuquay-Varina,
NC 27526.
2)
A mandatory pre-bid meeting will be held on Tuesday, January 20, 2015, at the FuquayVarina Community Center at 10:00 a.m. The Community Center is located at 820
South Main Street, Fuquay-Varina, NC 27526.
3)
Sealed bids must be submitted to Deborah Freeze, Assistant Finance Director, Town of
Fuquay-Varina, NC, at the Fuquay-Varina Town Hall, 401 Old Honeycutt Road,
Fuquay-Varina, NC 27526, and they shall be clearly marked on the outside of any
envelope as “FALCON PARK CONCESSION/RESTROOM FACILITY” prior to the
official opening time.
4)
Bids will be opened at 10:00 a.m. on Friday, January 30, 2015, at the Fuquay-Varina
Town Hall, 401 Old Honeycutt Road, Fuquay-Varina, NC 27526. Any bids received
after that time will not be considered. Bidders are encouraged to be present at the
opening in order to answer any questions that might be necessary to evaluate their bids.
5)
The Contractor submitting a bid for this project must possess a North Carolina
Contractor license classification to perform the Work contained in the specifications in
accordance with North Carolina General Statutes; and if selected, provide a copy of
their active license to the Owner.
6)
The Town of Fuquay-Varina reserves the right to reject any or all bids.
Questions concerning the Falcon Park Concession/Restroom Facility shall be directed to:
Jonathan Cox, Parks, Recreation & Cultural Resources Director, 919-552-1430.
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
1 of 27
INFORMATION FOR BIDDERS
Separate, sealed informal bids will be received by the Town of Fuquay-Varina (herein called the
OWNER) at the Fuquay-Varina Town Hall in the Conference Room until 10:00 a.m. on Friday,
January 30, 2015 and then at said office publicly opened and read aloud.
Each proposal shall be submitted in a sealed envelope, addressed to Office of the Assistant Finance
Director, Town of Fuquay-Varina, 401 Old Honeycutt Road, Fuquay-Varina, North Carolina 27526.
Each sealed envelope containing a bid must be clearly marked on the outside as a bid for
“Falcon Park Concession/Restroom Facility “
The envelope shall also be marked with the Bidder’s name, address, and name and phone number of a
contact person. If forwarded by mail, the sealed envelope containing the bid must be enclosed in
another envelope addressed to the Owner, c/o Office of Assistant Finance Director, Town of FuquayVarina, 401 Old Honeycutt Road, Fuquay-Varina, North Carolina 27526.
No oral interpretations will be made as to the meaning of the Contract Documents. Interpretation, if
deemed necessary, will be in the form of a written Addendum.
All bids must be made on the required form. All blank spaces for bid prices must be filled in, in ink or
typewritten, and the form must be fully completed and executed when submitted. Only one copy of
the bid form is required. Altered bid forms will be rejected. A conditional or qualified bid will not be
accepted.
The Owner may waive any informalities or minor defects or reject any and all bids. Any bid may be
withdrawn prior to the above scheduled time for the opening of bids or authorized postponement
thereof. Any bid received after the time and date specified shall not be considered. No bidder may
withdraw a bid within 60 days after the actual date of the opening thereof. Should there be reasons
why the contract cannot be awarded within the specified period, the time may be extended by mutual
agreement between the Owner and the Bidder.
Bidders must satisfy themselves of the accuracy of the Work description by examination of the site and
review of drawings and specifications including addenda. The failure or omission of any Bidder to do
any of the foregoing shall in no way relieve any Bidder from any obligation in respect to his/her/its
bid. After bids have been submitted, the Bidder shall not assert that there was a misunderstanding
concerning quantities of Work or the nature of the Work to be done.
The contract documents contain the provisions required for the construction of the project.
Information obtained from an officer, agent, or employee of the Owner or any other person shall not
affect the risks or obligations assumed by the Contractor or relieve him/her from fulfilling any
conditions of the contract.
The Owner may make such investigations as he/she deems necessary to determine the ability of the
Bidder to perform the Work, and the Bidder shall furnish to the Owner all such information and data
for this purpose as the Owner may request. The Owner reserves the right to reject any bid if the
evidence submitted by, or investigation of, such Bidder fails to satisfy the Owner that such Bidder is
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
2 of 27
properly qualified to carry out the obligations of the agreement and to complete the Work
contemplated therein.
The award of the Contract, if it is awarded, will be to the lowest responsive, responsible Bidder whose
qualifications indicate the award will be in the best interest of the Owner. The Owner reserves the
right to waive technicalities and/or reject any or all proposals.
The low Bidder shall supply the names and addresses of material suppliers and subcontractors when
requested to do so by the Owner.
The party to whom the contract is awarded will be required to execute the Contract within ten (10)
calendar days from the date when the Notice to Award is delivered to the Bidder. The Notice of
Award shall be accompanied by the necessary agreement forms. In case of failure of the Bidder to
execute the agreement, the Owner may, at his option, consider the Bidder in default.
The Owner, within five (5) calendar days of receipt of an acceptable agreement, signed by the party to
whom the bid was awarded, shall sign the agreement and return to such party an executed duplicate of
the agreement. Should the Owner not execute the agreement within such period, the Bidder may by
written notice withdraw his signed agreement. Such notice of withdrawal shall be effective upon
receipt of the notice by the Owner.
The Notice to Proceed shall be issued within five (5) calendar days of the execution of the agreement
by the Owner. Should there be reasons why the Notice to Proceed cannot be issued within such a
period, the time may be extended by mutual written agreement between the Owner and the Contractor.
If the Notice to Proceed has not been issued within the five (5) calendar days period or within the
period mutually agreed upon, the Contractor may terminate the agreement without further liability on
the part of either party.
A Performance Bond and a Payment Bond, each in the amount of one hundred percent (100%) of the
contract price, with a corporate surety approved by the Town of Fuquay-Varina, will be required for
the faithful performance of the contract. Bidders shall provide certification that performance and
payment bond sureties are licensed in North Carolina. Alternate equivalent sureties will be accepted
on a case by case basis.
All applicable laws, ordinances, and the rules and regulations of all authorities having jurisdiction over
the project shall apply to the contract throughout.
Time is of the essence as to Contractor’s performance of the Contract Work herein described and that
Owner will suffer a financial loss if the subject Contract Work is not completed within the time
prescribed herein. Successful Bidder will agree that as liquidatable damages (and not as a penalty)
Contractor shall pay the Town of Fuquay-Varina $300.00 per day every calendar day of delay for the
project not being substantially complete after six (6) months from receipt of the Notice to Proceed.
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
3 of 27
BID
Town of Fuquay-Varina
Construction of a Concession/Restroom Facility at Falcon Park
TO:
THE TOWN OF FUQUAY-VARINA, NORTH CAROLINA (“Owner”)
FROM: “BIDDER”
ADDRESS
DATE OF BID
, 20
The Bidder hereby signifies that it is his/her/its/its intention and purpose to enter into a formal Contract with the
Town of Fuquay-Varina, North Carolina, to furnish all labor, materials, tools, equipment, apparatus, supplies,
and the like required, and to do all the Work necessary, for and because of the construction, erection, and/or
installation of the proposed “Project”:
Concession/Restroom Facility at Falcon Park
for the Town of Fuquay-Varina, North Carolina in accordance with the Contract Documents, including Addenda
attached thereto**
under the conditions of and in accordance with the terms of this Bid
Proposal, which are as follows:
THAT: The Bidder has carefully examined the Plans and Specifications and all other Contract Documents and
fully understands them.
THAT: The Bidder has carefully examined the site of the Project and is familiar with the conditions under
which the Work, or any part thereof, is to be performed and the conditions which must be fulfilled in furnishing
and/or installing, erecting or constructing any or all items of the Project.
THAT: The Bidder shall provide all necessary tools, machinery, equipment, apparatus, and all other means
necessary to do all the Work and shall furnish all labor, materials and all else required to complete such Contract
as may be entered into, in the manner prescribed in and in accordance with the terms of the Specifications and
the Contract and in accordance with the true intent and meaning thereof, and in accordance with the Plans and/or
Drawings and the requirements of the Design Engineer under them, in a first class manner.
[Terms continued on the following page.]
** Fill in appropriate Addenda number(s):__________________________________________
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
4 of 27
THAT: Owner may reject any and all bids and award the contract to the bidder that it determines, in its sole and
absolute discretion, to be the lowest responsible bidder after taking into consideration the best interest of Owner.
THAT: The Work under each Section of the Technical Specifications will be awarded under one Contract and
the Owner shall have the right to include or exclude such component(s) of Work under each Section of the
Technical Specifications as the Owner may deem to be in the best interests of the Owner, and reduce the Bid
price accordingly.
THAT: Upon being notified of being the apparent lowest responsible Bidder, the Bidder shall execute a
Performance Bond and a Payment Bond, on the forms included herein, each equal to one hundred percent
(100%) of the Contract Price (Contract Sum), as security for the faithful performance of the Contract and
payment for all materials and labor.
THAT: The Bidder shall submit, in the blank spaces provided, all data, guarantees and other information called
for.
THAT: This Bid Proposal shall be signed and submitted in the manner prescribed in the Instructions to Bidders.
THAT: The Bidder shall be prepared to execute a Contract within the time specified in the Information to
Bidders.
THAT: The Bidder proposes to enter into a Contract in accordance with this Bid Proposal, the Plans and
Specifications and the Contract Documents included herein, for the prices shown on the following pages.
THAT: The successful Bidder shall be required to submit a complete detailed cost breakdown of the Lump Sum
Bid Price amount (if project is a lump sum bid) for payment purposes, for approval by the Engineer, prior to the
Award of the Contract.
THAT: It is the intent of these Contract Documents to obtain a Contract Price based on a combination of Lump
Sum Prices and Unit Prices with estimated quantities. Where a discrepancy exists between words and numbers
in the Bid amount, the written words shall govern. Where a discrepancy exists between unit prices and
mathematical computations in the Itemized Proposal, the unit prices and quantities in the Itemized Proposal shall
govern.
THAT: The successful Bidder shall have all proper Contractor licenses with applicable classifications and
privilege licenses required under North Carolina state laws governing their respective trade(s), and be in good
standing with their respective North Carolina Licensing Board.
THAT: The lowest bid will be determined by the total cost of the Contract with the prices of and alternates
accepted being added to or deducted from the Base Bid to give the total cost of the project. (If there is to be no
change in price for an alternate, please so state. Indicate by plus or minus sign for all alternates whether the
alternate is to be added to or deducted from the base bid. Bidders are required to give a price for the Lump Sum
Base Bid and all Alternates.)
BASE BID FOR CONSTRUCTION OF A CONCESSION/RESTROOM FACILITY:
$______________________________
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
5 of 27
(IF AN INDIVIDUAL, PARTNERSHIP OR NON-CORPORATE ORGANIZATION)
Signature of Bidder _______________________________________________________
By: _________________________ Address: ___________________________________
Names & Addresses of Members of Firm
__________________________________________________________________________________
__________________________________________________________________________________
____________________________________________________
(IF A CORPORATION)
Signature of Bidder _______________________________________________________
By: _________________________ Address: ___________________________________
Incorporated under the Laws of the State of ____________________________________
President: _______________________________________________________________
Name and Address
Secretary: _______________________________________________________________
Names and Address
Treasurer: _______________________________________________________________
Name and Address
Required License
North Carolina General Contractor license number: _______________________________
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
6 of 27
ADDITIONAL BIDDER’S CERTIFICATION
Acceptance of Terms
In submitting this Bid Proposal, the undersigned agrees that this bid will remain in effect for a period
of 60 days following the opening of the Bids, that the undersigned agrees to enter into a Contract with
the Owner, if awarded, on the basis of this Bid Proposal, and that the undersigned agrees to complete
the Work in accordance with the Contract Documents.
Non-Collusion in Bidding
The Bidder specifically agrees to abide by all applicable provisions of Article 3 of Chapter 133 of the
North Carolina General Statutes. By submission of this Bid, each Bidder and each person signing on
behalf of any Bidder certifies, and in case of a joint Bid each party thereto certifies as to its own
organization, under penalty of perjury, that to the best of knowledge and belief:
1) The prices in this Bid have been arrived at independently without collusion, consultation,
communication, or agreement, for the purpose of restricting competition, as to any matter relating
to such prices with any other Bidder or with any competitor;
2) Unless otherwise required by Law, the prices quoted in the Bid have not been knowingly disclosed
by the Bidder and will not knowingly be disclosed by the Bidder prior to opening, directly or
indirectly, to any other Bidder or to any competitor; and
3) No attempt has been made or will be made by the Bidder to induce any other person, partnership,
or corporation to submit or not to submit a Bid for the purpose of restricting competition.
Type of Business
The undersigned hereby represents that it is a ___________________________________
(corporation, partnership, or an individual). If a corporation, the undersigned further represents that it
is duly qualified as a corporation under the Laws of the State of North Carolina and it is authorized to
do business in this State.
________________________________
Firm
___________________________
Date
________________________________
Authorized Signature
______________________________
Title
___________________________
Name of Project
__________________________________________________
Address of Firm
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
7 of 27
CONSTRUCTION PAYMENT BOND
(Attach to this page)
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
8 of 27
CONSTRUCTION PERFORMANCE BOND
(Attach to this page)
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
9 of 27
TECHNICAL
SPECIFICATIONS
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
10 of 27
Falcon Park Concession/Restroom Facility
Falcon Drive
Fuquay-Varina, North Carolina
CONSTRUCTION SPECIFICATIONS
1. GENERAL REQUIREMENTS:
Part 1 Definitions
A.
Owner: The term ‘Owner’ shall mean the Town of Fuquay-Varina, North
Carolina
B.
Architect: The term ‘Architect’ shall mean TOFV (Town of Fuquay-Varina)
401 Old Honeycutt Rd. Fuquay-Varina, NC 27526.
C.
Contractor: The term ‘Contractor’ shall mean that General Contractor (individual
or entity) enlisted by the Town of Fuquay-Varina to construct the subject project.
D.
Contract Documents: All work encompassed by the drawings, schedules, and
specifications or required by the contract for a complete and finished project,
including all addenda, change orders and work orders which may amend the
original documents. All work above shall be accomplished under a single prime
contract agreed upon between the Owner and the Contractor.
Part 2 Administration of the Contract
A.
The Scope of the Work shall include all labor, materials, equipment, temporary
services (including utilities, tap fees, toilets, space heating, generators, etc.),
permits and fees necessary to complete the job as shown in Construction
Documents dated December 18, 2014.
B.
The Contractor shall perform all work required under the contract in a good
workmanlike manner, in accordance with the contract documents. He shall
assume responsibility for the condition of the workplace with regard to safety,
security, and adherence to all applicable governmental regulations. All materials
shall be new and inspected for fitness for the use intended, and all work shall
conform to all applicable codes and ordinances.
C.
No changes or material substitutions shall be made to the contract documents
unless agreed to in writing by the Owner, Architect and Contractor.
D.
Contractor shall arrange for all inspections required during the course of
construction by all governmental agencies.
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
11 of 27
E.
Contractor shall haul away all debris from the site on a periodic basis and shall
maintain dumpster service on site if required by the governing authorities.
F.
Contractor shall provide all tools and machinery necessary to accomplish the
work.
G.
Contractor shall provide a one year warranty on all labor and materials, and a
longer warranty on all items where the manufacturer provides such warranty.
2. SITEWORK
Part 1 Execution
A. Excavation:
1. Contractor shall grade site as indicated on the drawings. Notify the Architect
if soil conditions are encountered which would create unsuitable conditions for
the construction, including but not limited to uncompacted fill, fill with
significant quantities of debris or organic material, wet or excessively clayey
soils, and underground springs or other groundwater, and bedrock or large
boulders which cannot be removed with ordinary earthmoving equipment.
2. Backfill: Contractor shall install backfill using materials and methods as
suitable for the condition encountered. Use only clean materials free of organic
matter.
3. All utility lines shall be extended underground from building to utility
connection. Connection charges shall be included in Base Bid. Contractor shall
contract ULOCO at 800-632-4949 two (2) days, and not more than ten (10) days
prior to beginning excavation in the public right-of-way.
4. Footing trenches shall extend into adequate bearing soil a minimum of 6”, and
be a minimum of 12” below finish grade. Provide fences, barricades, or any other
safety devices around all open trenches, excavations or any other hazardous area.
Protect all graded and excavated areas from traffic and erosion.
5. Use tree protection measures where required by the governing authorities.
Take care to avoid damaging vegetation to remain and do not store soil or
significant quantities of material within the drip line of trees to remain.
6. Grade rough driveways as needed to access the site during construction.
Install crush & run stone as needed to serve temporary access needs. Remove
crush & run when work is complete.
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
12 of 27
7. Fine grade all areas adjacent to the building. Seed and straw areas shown on
the Site Plan.
8. Provide bonded termite protection, installed by licensed applicator per
instructions from manufacturer and regulations for State of North Carolina.
Provide Certificate of Application to Owner.
3. CONCRETE
Part 1 Products
A. Concrete/Reinforcing
1. All concrete shall be 3000 psi minimum strength in 28 days.
2. Reinforcing Bars shall conform to ASTM Specification A625, Deformed
Bars, with a minimum yield stress of 60, 000 psi. Provide wire chairs below
all rebar and take care that rebar has adequate concrete coverage.
3. Vapor barrier for concrete slab shall be minimum 6mil with all joints
overlapped and taped.
Part 2 Execution
A. Footings
1. Footings shall be sized as shown and shall be reinforced with (2) #5 bars each
way.
2. No concrete shall be placed if it will be subjected to freezing with 24 hours, on
frozen ground, or in standing water.
B.
Slab
1.
Building slab elevation to be .2 (2 tenths) higher than the existing concrete
around the building slab.
4. MASONRY
Part 1 Products
A. Exterior Veneer
1. Adams concrete split-block for exterior walls
2. Interior walls to be 8” x 16” x 8” concrete block.
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
13 of 27
3. Lintels over openings to be primed and sized in accordance with the North
Carolina State Building Code.
4. Eave height is 8 feet.
Part 2 Execution
A. Masonry Construction
1. All masonry construction and masonry reinforcement to be in accordance with
the North Carolina State Building Code.
2.
Flowable fill is required in reinforced areas only.
5. METALS
A. Fence and gate surround (HVAC condenser unit)
1. Shall be constructed of wrought iron; 42” high, posts 1” square tube 16
gauge, pickets ½” x ½” solid square bar max spacing 4”, top and bottom
rail 1” x ½” x 1/8” channel.
6. WOOD AND PLASTICS
Part 1 Products
A. Rough Carpentry
1. Floor joists, roof rafters, trusses, structural headers, and girders shall be #2 or
better kiln dried Southern Yellow Pine
2. Wall studs and ceiling joists shall be #2 or better kiln dried Spruce-Pine-Fir.
3. Wood in contact with concrete shall be pressure-treated; ground contact
approved Southern Yellow Pine.
4. Metal framing connections where noted shall be by Simpson Company or
equal. Comply with N.C. Building Code and local Building Inspectors for
required tie-downs.
5. Exteriors connectors shall be hot-dipped galvanized.
6. Roof to have 5/12 pitch
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
14 of 27
Part 2 Execution
A. Rough Carpentry
1. Set still plates in two continuous caulk beads.
2. Provide continuous solid blocking as required for toilet accessories, cabinets,
etc.
3. Floor joists shall be checked for dimensional regularity prior to installation and
shall be installed crown side up.
B. Finish Carpentry
1. Install woodwork plumb, level, true and straight with no distortions. Shim as
required using concealed shims. Install to a tolerance of 1/8” in 8’-0’ for plumb
and level with no variations in flushness of adjoining surfaces.
2. Install all trim with minimum number of joints possible, using full length
pieces (from maximum length of lumber available). Stagger joints in adjacent
and related members.
7. THERMAL AND MOISTURE PROTECTION
Part 1 Product
A. Roofing and Flashing
1. Three tab asphalt roofing shingles (30 year), color specified by owner.
2. Ridge vent shall be provided and installed per manufacturer’s requirements.
B. Insulation and Accessories
1. Insulation shall be fiberglass of R-values and facing as indicated.
2. Vapor barrier shall be 4 mil minimum.
3. Exterior house wrap shall be “Tyvek”.
4. Block fill all exterior walls / foam core fill
C. Caulking
1. Interior caulking shall be acrylic latex.
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
15 of 27
2. Exterior caulking shall be high performance silicone.
D. Siding
1. Exterior siding to be hardi plank. Color and style to be specified by owner.
Part 2 Execution
A. Install all manufactured products in strict accordance with the manufacturer’s
instructions
B. All products shall be installed to provide a complete barrier to moisture penetration.
8. DOORS AND WINDOWS
Part 1 Products
A. Doors and Hardware
1. Exterior doors shall be flush steel with factory applied primer finish. Door
frames shall be metal. Republic – steel door-DL series – 16ga. (DL-F) or
comparable.
2. Door thresholds shall be accessible ¼” saddle design, mill finish aluminum,
National Guard.
3. Weather stripping and door sweep shall be silicone gasketing, natural satin
anodized, National Guard.
4. Door hinges shall be 5 knuckle, flush ball bearing design with brushed chrome
finish, sized to match doors, Stanley.
5. Door closers on each door shall be LCN 1460 series top jamb interior mount,
adjusted to meet minimum requirements for accessibility.
6. Door hardware on each door shall be Schlage AL series “Neptune” lever
(AL 10S) and B100 series single cylinder deadbolt (B160N)l.
B. Windows
1. Concession window (4’ x 8’) by Cornell model #PBI 5F 22GP or comparable.
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
16 of 27
9. FINISHES
Part 1 Products
A. Interior Finishes
1. Gypsum board ceilings shall be 5/8” moisture resistant, type “x”.
2. All interior floor and base finishes shall be smooth finished concrete epoxy
paint sealed with abrasive grain particles added for additional slip resistance,
or equal.
3. Coatings:
4. Interior block walls shall be:
First coat - Acrylic block fill primer.
Second & Third coats – Acrylic semi-gloss paint. Color to be specified by owner.
5. Gypsum board ceilings, doors, cabinets, & trim shall be:
First coat – Acrylic primer.
Second & Third coats - Acrylic semi-gloss paint. Color to be specified by owner
B. Exterior Finishes
All stain shall be by Benjamin Moore, or equal.
1. Exterior stain: Exposed exterior wood siding and trim shall be:
First and Second Coats: Moorwood Acrylic Solid Color Stain
2. Exterior Block: Seal all split faced block using block seal
First and second coats to be enamel, color by owner
3. Metal Fence/Gate : to be primed and painted black
Part 2 Execution
A. Gypsum Board
1. Examine framing and blocking and weather protection for defects which would
adversely affect the gypsum board installation. Provide for proper panel support
around all openings and cutouts.
2. Verify that insulation has been placed in an acceptable manner and that
inspection of framing, electrical, mechanical and plumbing rough in work has
been completed before beginning the installation.
3. Install vapor barriers on interior face of all exterior stud wall areas prior to
gypsum board installation.
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
17 of 27
4. Install board in maximum practical lengths to span surfaces with a minimum
of end butts joints. Where butt joints occur, stagger the vertical joints between
courses.
5. Screw apply boards at walls and ceilings.
6. Mix and apply adhesive and joint finishing compounds in strict accordance
with manufacturer’s directions. Do not tape and bed joints if they will be
subjected to freezing. Allow joint compound to dry between coats. Extend each
coat slightly beyond previous coat. Sand between coats and after final application
of compound in order to provide a smooth surface. Avoid roughing surface of
wallboard. Leave wallboard areas smooth and uniform, ready for painting.
C. Paints and Finishes
1. Prepare samples of each type of paint specified on site for approval.
2. Examine surfaces scheduled to receive paint. Do not proceed with painting
work in each location until unsatisfactory conditions have been corrected in a
manner acceptable to applicator. The beginning or work in a specific area shall
be construed as acceptance of the surfaces by the applicator as satisfactory to
produce proper finished surfaces.
3. Protect carefully all adjacent surfaces not being painted concurrently or not to
be painted.
4. Surfaces to be painted or finished shall be clean, dry, smooth and free from
dust and all foreign matter which will adversely affect adhesion or appearance.
Perform preparation and cleaning procedures in strict accordance with the paint
manufacturer’s instructions and as herein specified, for each particular substrate
condition.
5. Exterior siding, block and trim shall be clean and dry. Apply primer or knot
sealer on new siding as recommended by manufacturer.
6. Workmanship shall be of high standard, by skilled mechanics using proper
types and sizes of brushed, roller covers, or airless spray equipment suitable for
finish required. Apply material evenly and uniformly under adequate illumination
completely covering surfaces, smooth and free from runs, sags, clogging and dust,
excessive roller stipple, and other imperfections.
7. Upon completion of painting work, clean window glass and other paint
spattered surfaces. Remove spattered paint by proper methods of washing and
scraping, using care not to scratch or otherwise damage finished surfaces.
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
18 of 27
8. Contractor shall leave painting schedule and one quart of each finish paint
material with Owner at completion of work.
10 SPECIALTIES
Part 1 Products
A. Toilet Compartments and countertops
1. Toilet compartments and countertops shall be as manufactured by Santana
Products, Inc. Toilet compartments shall be floor supported and overhead braced.
Countertops shall be fully wall supported with under counter braces of like
material, with 4” backsplash and 6” skirt. Color shall be as selected by Owner
from Deluxe 1000 series.
B. Bath Accessories
1. Toilet tissue dispensers shall be B-686, type 304 stainless steel as
manufactured by Bobrick. One per toilet compartment.
2. Paper towel dispenser/water receptacle shall be B-38032, type 304 stainless
steel as manufactured by Bobrick. One per bathroom.
3. Lavatory mounted soap dispenser shall be B-8226, type 304 stainless steel as
manufactured by Bobrick. One per lavatory.
4. Grab bars shall be B-5507.99, peened gripping surface with satin finish ends,
type 304 stainless steel, as manufactured by BobricK. In accessible toilet
compartment as indicated.
5. Mirrors shall be B-290 by Bobrick, with one piece roll formed frame of 304
stainless steel angle and no. 1 quality ¼” float/plate glass mirror electrolytically
cooper plated. One per lavatory as indicated.
Part 2 Execution
A
Install all manufactured products in strict accordance with manufacturer’s
instruction and with required attachments to adjacent materials.
11 EQUIPEMNT (not used)
12 FURNISHING (not used)
13 SPECIAL CONSTRUCTION (not used)
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
19 of 27
14 CONVEYING SYSTEMS (not used)
15 MECHANICAL
Part 1 Products
A. Plumbing
1. Plumbing plans as shown are schematic. Design of the plumbing system shall
be the responsibility of General Contractor’s selected plumbing contractor.
Systems shall be designed to be consistent with best engineering practice and in
accordance with all codes and authorities.
2. Water lines shall be copper.
3. Waste lines shall be PVC.
4. Water heater and plumbing fixtures shall be as scheduled, with all required
accessories necessary for complete installation.
Part 2 Execution
A. Plumbing
1. Provide all plumbing supply, vent and drain lines needed for a complete
system with fixtures as shown on the drawings and as scheduled. Install piping in
a neat and workmanlike manner, and avoid drilling through the top or lower third
of joists or except in the center studs. Advise contractor if additional framing
adjustments are needed to accommodate plumbing. Connect vents where
practicable to minimize roof penetrations, and locate vents on rear side of
building when possible. Locate clean-outs and other visible rough plumbing
elements so as to be as visually unobtrusive as possible.
2. Provide 1 water outlet in each bathroom, and 1 exterior water outlet as
indicated.
3. Insulate all water lines with ¾” flexible rubber insulation.
4. Support waste lines at maximum of 8’ -0” o.c.
5. Provide cut-off valves for all lavatories, toilets, and other plumbing fixtures.
6. Provide all connections to the public water and sewer system and pay for all
tap fees
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
20 of 27
B. Heating and Air Conditioning
Part 1 Products
A. Central heating and air condition system consisting of a 1.5ton unit installed in the
attic. Manufacturer – Trane, Ruud, Carrier
Part 2 Execution
A. All HVAC equipment and accessories is to be installed in accordance with the North
Carolina State Mechanical Code.
16 ELECTRICAL
Part 1 Products
A.
Electrical plans as shown are schematic. Design of the plumbing system shall be
the responsibility of General Contractor’s selected electrical contractor. Systems
shall be designed to be consistent with best engineering practice and in
accordance with all codes and authorities.
B.
Provide specified items and any items required by Code
C.
Switches and receptacles shall be white plastic.
D.
All wiring except from transformer to meter base shall be copper.
E.
Power wiring shall be underground to meter with all fees for connection service to
be in base bid. Provide exterior rated main panel at the exterior rear of new
building.
Part 2 Execution
A. Provide all wiring, fixtures and electrical devices shown on the
drawings or required by the Building Code for a complete and finished
electrical system in accordance with the NEC (National Electrical
Code)
SEE ATTACHED FOR SPECIFICATIONS OF ITEMS NOT NOTED ABOVE.
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
21 of 27
FALCON PARK CONCESSION STAND SPECIFICATIONS
PLUMBING
Manufacturer
Description
Model #
Quantity
Belson
Outdoor Drinking Fountain (silver)
1025
Rheem / Ruud
30 Gallon Commercial Water Heater
EGSP30
1
American Standard
Urinal
Allbrook
1
Sloan
Continental Flushometer
186
1
American Standard
EL Flush ValveToilet
3641.016
3
American Standard
Plastic Toilet Seat
5309.110
3
Sloan
Royal II Flushmeter
110
3
American Standard
Restroom Sink
Colony Oval Counterop
4
American Standard
Restroom Sink Faucet
2275.409
4
American Standard
Concession Sink - Double Bowl
7502.103
1
American Standard
Concession Sink Faucet
6279.000
1
Watts
Backflow Preventer 1”
909QT
1
Watts
Pressure Reducing Valve 1”
223SB
1
Description
Model #
Excel
Xlerator Hand Dryer
XL-BW
H.E. Williams
2 Lamp Lighting Fixture
H.E. Williams
Exterior Light Fixture
WP1-CLF
2
Air King
Energy Star In-line Exhaust Fan 100CFM
AIK14X
2
Lithonia
Emergency Light Fixture
EU2M6
3
Lithonia
LED Exit Sign
LHQM SW 3R HO R0
3
Atlas
100w / Wall Mount Exterior Light
WLG11
4
Manufacturer
Description
Model #
Quantity
Adams Products
Concrete Split-block / Natural Finish
Asphalt Shingle
3Three Tab (color by owner)
30year
Republic
Steel Doors-DL Series -16 guage -Lockset w/deadbolt
DL-F
5
Cornell
Concession Window (8' x 4')
PBI 5F 22GP
1
Rainhandler
Aluminum 4" Gutters / 2" x 3" Drops
Signage
Restroom/Concession/ storage/
White
Per code
Manufacturer
Description
Model #
Bobrick
Mirror
B-165 4836
2
Bobrick
Multi-roll Toilet Tissue Dispenser
B-2888
3
Bobrick
Soap Dispenser
B-2111
3
Watts
Floor Drains
FD-103
4
Koala Kare Products
Baby changing station
KB200
2
C R Laurence
48" Stainless Steel Grab Bars
B49048
2
C R Laurence
36" Stainless Steel Grab Bars
B49036
2
Bobrick Bathroom Partitions
Solid Polymer - Overhead / Head Braced Style - Serra Series (SCRC)
2
ELECTRICAL
Manufacturer
Quantity
2
8
EXTERIOR
INTERIOR
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
Quantity
22 of 27
HVAC
Manufacturer
Description
Trane / Carrier / Ruud
1.5 Ton Unit
Model #
Quantity
1
FALCON PARK CONCESSION STAND SPECIFICATIONS VENDOR
CONTACTS
Belson Outdoors, Inc.
111 North River Road
North Aurora, IL 60542
Phone:
(630) 897-8489
Fax:
(630) 897-0573
Toll Free: (800) 323-5664
Rheem / Ruud
Ed Briggs Htg & A/C
7925 Twin Pines Way
Fuquay-Vorina, NC 27526
Phone: (919) 772-6724
NORMANS HEATING & COOLING LLC
1135 BRIDLEMINE DR
FUQUAY-VARINA, NC 27526
Phone: (252) 799-8228
American Standard
Noland Company
1117 CAPITAL BLVD
RALEIGH, NC 27603
Phone: 919-832-2071
Watts
Smith & Stevenson Co.
4935 Chastain Avenue
Charlotte, NC 28224
P 704.525.3388
F 704.525.6749
Excel Dryer Inc.
357 Chestnut Street
P.O. Box 365
East Longmeadow, MA 01028
1-800.255.9235
H E Williams Lighting
MB Widerman & Assoc. Inc.
113 James Circle Eden, NC, 27288
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
23 of 27
Phone: 336-722-5154
Fax: 336-722-5155
Air King
820 Lincoln Avenue
West Chester, PA 19380
Phone: 877-304-3785
Fax: 610-696-8048
Email: [email protected]
Adams Products
Morrisville, NC Production Facility
P. O. Box 189
5701 McCrimmon Parkway
Morrisville, NC 27560
Office: (800) 672-3131
Office: (919) 467-2218
Main Fax: (919) 469-0509
Dispatch Fax: (919) 469-9539
Sales Fax: (919) 467-9113
Hardscape Fax: (919) 319-8708
Sloan
CAROLINA PLUMBING SUPPLY INC
4601 TRADEMARK DR RALEIGH, NC 27610-3059
P: 919 876-1424
F: 919 876-8678
WILKINSON SUPPLY CO
3300 BUSH ST RALEIGH, NC 27609-7505
P: 919-834-0395
F: 919-834-0253
Lyons Roofing & Supply
349 Lenoir Rhyne Blvd.,
Hickory North Carolina 28602
1-800-524-6030
Cornell
Passport Door Systems
P O Box 1840
Angier, NC 27501
P 919-639-0334
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
24 of 27
F 919-639-8939
Email: [email protected]
Republic Doors
Godwin Door & Hardware, Inc.
Phone: 919-580-0543
Bobrick
Martin Architectural Building
Maryann Payne
511 E Chatham Street
Cary, NC 27511
919-469-9661
FAX: 919-469-9630
Rainhandler
Toll Free: 1-800-942-3004
Fax: (800) 606-2028
C. L. Laurence
www.crlaurence.com
1-800-421-6144
Lithonia Lighting
PO Box A
Conyers, GA 30012
Phone: 770-922-9000
Fax: 770-483-2635
Grainger
Branch: 637
4820 Signett Dr.
Raleigh, NC 27616-2824
Phone: (919) 790-0888
Fax: (919) 850-9423
Koala Kare Products-Bobrick
Martin Architectural Building
Maryann Payne
511 E Chatham Street
Cary, NC 27511
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
25 of 27
919-469-9661
FAX: 919-469-9630
CONSTRUCTION
DRAWINGS
Town of Fuquay-Varina
Falcon Park Concession/Restroom Facility
26 of 27